96/77/EC: Commission Decision of 18 January 1996 establishing the conditions for the harvesting and processing of certain bivalve molluscs coming from areas where the paralytic shellfish poison level exceeds the limit laid down by Council Directive 91/492/EEC (Text with EEA relevance)

• CELEX: Directive 91/492/EEC
• Articles: 5

Article 1

This Decision applies only to the bivalve molluscs belonging to the species Acanthocardia tuberculatum.

Article 2

1. Spain can authorize the harvesting of the bivalve molluscs referred to in Article 1 in production areas where the PSP level in the edible parts of these molluscs is higher than 80 ìg for 100 g but lower than 300 ìg for 100 g.

The harvested molluscs must:

- be transported in containers or vehicles sealed by the competent authority, directly to an approved establishment, especially authorized to carry out their treatment,

- be accompanied by a document issued by the competent authority which authorizes the transport, attesting to the nature and quantity of the product, area of origin and plant of destination,

- the subjected to the heat treatment defined in the Annex to this Decision.

2. The final products resulting from the molluscs referred to in paragraph 1 must not contain a PSP level detectable by the bioassay method after the application of this heat treatment. Each lot shall be tested. This provision will be reviewed six months after the entry into force of this Decision following a report presented by the Spanish authorities.

Article 3

The competent authority shall check that the 'own health` checks provided for in Article 6 of Council Directive 91/493/EEC (3), drawn up and implemented by the person responsible for the establishment authorized in accordance with Decision 94/356/EC, shall apply specifically to the heat treatment defined in the Annex to this Decision.

Article 4

This Decision is addressed to the Member States.

Done at Brussels, 18 January 1996.

For the Commission

Franz FISCHLER

Member of the Commission

(1) OJ No L 268, 24. 9. 1991, p. 1.

(2) OJ No L 156, 23. 6. 1994, p. 50.

(3) OJ No L 268, 24. 9. 1991, p. 15.

Schedules & Appendices

ANNEX

Heat treatment applicable to bivalve molluscs Acanthocardia tuberculatum with the objective of reducing the PSP toxin to a level lower than 80 ìg per 100 g

Molluscs have to undergo the following operations sequentially:

1. Preliminary cleaning in fresh water for a minimum of two minutes at a temperature of 20 °C, plus or minus 2 °C.

2. Pre-cooking in fresh water for a minimum of three minutes at a temperature of 95 °C, plus or minus 5 °C.

3. The separation of flesh and shells.

4. Second cleaning in running fresh water for a minimum of 30 seconds at a temperature of 20 °C, plus or minus 2 °C.

5. Cooking in fresh water for a minimum of nine minutes at a temperature of 98 °C, plus or minus 3 °C.

6. Cooling in running cold fresh water for approximately 90 seconds.

7. The separation of the edible parts (foot) from the non-edible parts (gills, visceras and mantle) mechanically with water pressure.

8. Conditioning in containers closed hermetically in a non-acidified liquid medium.

9. Sterilization in autoclave at a minimum temperature of 116 °C for a time calculated according to the dimension of the containers used but which can not be lower than 51 minutes.